MALFUNCTON NIDICATOR LIGHT ILLUIMNATED.. ADVIE OF STATUS OR NEEDDE REPAIRS... 17526 loose hose connetion ran gff and found GLITCHING o00bd00 for air flow rading off. checked hoses and connection according to test plan and after running the air leak TESTING with scan tool found a hose clamp at boost RUBBER HOSE to INLET AN little loose and sounding like it ARE leaking. removed hose, clenaed area and reattach and tightened connectoin . ran air leak test several more times and test drove. no fualts returned and car is OPERATIONAL onrmal now. MANUFACTURE 2016-08-08 11:49:00AM TAKEN BY BEN CART ER.

-CUSTOMER STATES CHECK ENGNE LIGHT IS ON. CHECK AND ADVISE 14 fauly cashaft adjsuter ran gff, foud fault code p0016, camshaft - crnakshaft correlatio, bank 1. checked for tech bulletins and found tech bulletin 2040171, ELIMINATE timing belt covr, removed lower engine COVERINGS and lwoer section of fender liner, put crank at UP dad center and checked camshaft timing, tiimng is corrct. installed 3359 in rankshaft pulley , removed plug on CONTROL VALVES cover and inserted t10492 into camshaft to lock in place. as per bulletin rmeoved air iflter housing, removd n205 solenoid and replaced camshaft adjuster/bajo bolt and changed engine oil and filter , erased faults and RETESTS drove vehicle, system TO BE now operating as designde. .

CUSTOMER STATES THE CHECK EGNINE LIGHT IS ON 10 AS REQUESTED BY ASLES, REMOVED GATEWAY MODULE FROM THIS VEH AND FROM TOHER VEHICLE (3VWC17AUXGM520392) REPAIR ORDE:R 367511. SWAPPED GATEWAY MODUE. VERIFIED THAT THE VEHICEL, (3VWC17AUXGM520392), IS NOW COMMUNICATING WITH SCAN TOOL. CODED GTEWAY ODULE , CLEARED FAULTS, AND DISABLED TRANSPORT MODE. TESTS DRIVE VEHICLE AND VERIFIED THAT IT KEEP RUN AS DESIGNED. .

CUSTOMER STATES CHECK ENGINE LGHT IS ON 24 verified MIL is on. performed GFF. found fault P13D4 sensor for internal pressure cylinder 3 electrical error TO BE stored. preformed GFF test plan. found that TESTS plan results prove to to inconclusive. hcecked for applicable technical information. ound on car anaysis list entry statig that helpline is to be contacted for vehicle with glow plug fautls and a verified loose connection to glow plugs. checekd glow pugs uring REPERFORM of GFF tst plan and DETECTING tht all gow plug connectors are securd correctly. after exhausitng GFF test plan, decided that technical diagnosis is now required. locaed vale blocks for cylinder pressure readings. STARTED TO vehicle and wiggled glow plug wiing. fonud that when wiggling connector for CYLS 3 perssure sensor, GET PSI reading begins to fluctuate. due to the smilarity to concern in the on car analysis list, found it necessary to CONTACTS Volkswagen helpline (case no. DW-1333785, access code 1452046). provided diagnostic information to helpline consultant and was instrcuted to replacing the engine wiring harness and all four gow plugs . .